TIUCC28063高效1300W電源轉換器參考設計

1、TI UCC28063高效1300W電源轉換器參考設計TI公司的UCC28063是具有改善的抗噪性能的自然交叉(Natural Interleaving)轉換模式功率因數校正(PFC)控制器,具有先進的可聽噪音性能,相位管理功能,輸入濾波器和消除輸出電容器紋波電流,可減小電磁干擾濾波器尺寸,非線性誤差放大器增益,無傳感器電流整形能簡化電路板布局并提高效率,主要用在100W到800W電源,游戲,數字轉模擬機頂盒和家庭音響系統,家用電器和馬達控制.本文介紹了UCC28063主要特性,框圖和應用電路,以及高效高功率系數1300W AC/DC電源參考設計PMP10948主要特性,電路圖,材料清單和PC

2、B設計文件.Optimized for consumer applications concerned with audible noise elimination, this solution extends the advantages of transition mode high efficiency with low-cost components to higher power ratings than previously possible. By utilizing a Natural Interleaving technique, both channels operate

3、as masters (that is, there is no slave channel) synchronized to the same frequency. This approach delivers inherently strong matching, faster responses, and ensures that each channel operates in transition mode.Expanded system level protections feature input brownout and dropout recovery, output ove

4、r-voltage, open-loop, overload, soft-start, phase-fail detection, and thermal shutdown. The additional FailSafe over-voltage protection (OVP) feature protects against shorts to an intermediate voltage that, if undetected, could lead to catastrophic device failure. Advanced non-linear gain results in

5、 rapid, yet smoother response to line and load transient events. Reduced bias currents improve stand-by power efficiency. Special line-dropout handling avoids significant current disruption and minimizes audible-noise generation.UCC28063主要特性:Input Filter and Output Capacitor Ripple-Current Cancellat

6、ionReduced current ripple for higher system reliability and smaller bulk capacitorReduced EMI filter sizePhase Management CapabilityFailSafe OVP with Dual Paths Prevents Output Overvoltage Conditions by Voltage-Sensing FailuresSensorless Current-Shaping Simplifies Board Layout and Improves Efficienc

7、yAdvanced Audible Noise PerformanceNon-linear Error-Amplifier GainSoft Recovery on OvervoltageIntegrated Brownout and Dropout HandlingReduced Bias CurrentsImproved Efficiency and Design Flexibility over Traditional Single-Phase Continuous Conduction Mode (CCM)Inrush-Safe Current Limiting:Prevents MO

8、SFET conduction during inrushEliminates reverse recovery events in output rectifiersEnables Use of Low-Cost Diodes without Extensive Snubber CircuitryImproved Light-Load EfficiencyFast, Smooth Transient ResponseExpanded System-Level Protections1-A Source/1.8-A Sink Gate Drivers40 to 125 Operating Te

9、mperature Range in a 16-lead SOICpackageUCC28063應用:AC/DC Power Supply - Dual Analog ControllerIndustry-Specific Drives - E-Bikes & E-ScootersMajor Appliances - Washers & DryersMotor Control: AC InductionPower Supply: AC/DC, Non-Iso, w/ PFC, 90WAC/DC Power Supply - Single Analog ControllerLighting: L

10、CD BacklightMilitary: Radar/Electronic WarfarePower Supply: AC/DC, Isolated, w/ PFC, 90W圖1.UCC28063功能框圖圖2. UCC28063典型應用框圖圖3. UCC28063典型交叉發送模式PFC預穩壓器電路圖高效高功率系數1300W AC/DC電源參考設計PMP10948PMP10948 is a high-efficiency, high power factor AC/DC power supply reference design using UCC28063 interleaved trans

11、ition-mode PFC controllers. There are two PFC stages in this design, 750W output power generates from one of the PFC stages and 550W output power generates from the other PFC stage. This design achieve 95.6% efficiency at 120VAC input and 98% efficiency at 220VAC input with over 1300W output power.1

12、300W電源參考設計PMP10948主要特性:Interleaved transition-mode PFC Boost converters for total 1300W output power95.6% efficiency at 120VAC/60Hz input and 1300W output98% efficiency at 220VAC/50Hz input and 1300W outputTest report is available圖4.1300W電源參考設計PMP10948外形圖(正面)圖5.1300W電源參考設計PMP10948外形圖(背面)圖6.1300W電源參考設計PMP10948電路圖(1)圖7.1300W電源參考設計PMP10948電路圖(2)圖8.1300W電源參考設計PMP10948電路圖(3)1300W電源參考設計PMP10948材料清單(BOM):圖9.1300W電源參考設計PMP10948 PCB設計圖(1) 圖10.1300W電源參考設計PMP10948 PCB設計圖(2)圖11.1300W電源參考設計PMP10948 PCB設計圖